TRABAJO YA PUBLICADO
Chemical ripening advances in Tucumán, Argentina
M. Fernanda Leggio Neme*, Sofía Fajre*, Eduardo R. Romero*, Luis G. Alonso* and Agustín Sánchez Ducca*
* Sección Caña de Azúcar, EEAOC. fleggio@eeaoc.org.ar
Abstract
The need to maximise potential for both the environment and sugarcane varieties has resulted in an increase in
the sugarcane area treated with ripeners in Tucumán, from 3000 ha in 1997 to approximately 115.000 ha at present. This
advancement was promoted by researchers at the Estación Experimental Agroindustrial Obispo Colombres (EEAOC) in
Tucumán, Argentina, who issued recommendations for the use of glyphosate as a ripener in 1997. Similarly, fluazifop-p butyl
was released for use as a ripener in 2001. In searching for new alternative ripeners, graminicides (clethodim and
haloxyfop-r methyl) and imazapyr began to be evaluated in 2000. After these trials, only clethodim was released for
commercial use in 2005. Imazapyr, despite being efficient, was discarded because of its high cost. In 2006, EEAOC
scientists started evaluating trinexapac-ethyl. This plant growth regulator (PGR) has shown potential to replace herbicide
ripeners. Trinexapac-ethyl is already being used as a ripener in Brazil, along with sulfometuron-methyl. The latter was
evaluated in 2007 in Tucumán, but sugarcane response was highly variable and inconsistent. Since 2010, the effect of
ethephon, a PGR that releases ethylene, has been evaluated with and without a graminicide. So far, sugarcane responses
have been satisfactory (with average Pol% cane increments of 0.41 and 0.62, respectively). Mineral nutrients applications
(phosphorus, potassium and boron) were also evaluated and showed considerable sucrose content increases in some
cases. This paper is a review of extensive studies conducted since 1994 by EEAOC researchers to provide growers with a
great number of products that could be used as sugarcane ripeners, under different agro-ecological conditions.
Key words: Sugarcane; Pre-harvest practice; Herbicides; Plant growth regulators; Mineral nutrients.
Resumen
Avances en la maduración química en Tucumán - R. Argentina
La necesidad de explotar al máximo el potencial azucarero de las variedades difundidas comercialmente logró incrementar la superficie madurada de 3000 ha (en 1997) a las actuales 115000 ha. Este crecimiento fue impulsado por investigadores de la Estación Experimental Agroindustrial Obispo Colombres (EEAOC), quienes en 1997, difundieron las recomendaciones para el uso de glifosato como madurador de la caña de azúcar. Hicieron lo propio también con el producto fluazifop-p butil en 2001. En búsqueda de nuevas alternativas químicas, continuaron las experiencias con dos graminicidas, cletodim y haloxifop-r metil, y un herbicida total: imazapir. En 2005 se difundió el uso de cletodim, al no haberse obtenido resultados satisfactorios con el otro graminicida, mientras que el imazapir, a pesar de resultar muy eficiente, tuvo que ser descartado por su elevado costo. Desde 2006, se ha estado evaluando a un regulador vegetal del crecimiento (PGR), el trinexapac-etil, que demostró tener potencial para reemplazar a los productos tradicionales. Junto al sulfometuron, ya se está utilizando en Brasil como madurador. Este último producto se estudió desde 2007 en Tucumán, pero las respuestas registradas en el cultivo han sido variables. Desde 2010 se evalúa el etephon, un PGR que libera etileno, solo y en combinación con un graminicida, con respuestas que han sido satisfactorias (con incrementos promedio de Pol% caña de 0,41 and 0,62, respectivamente). Otra alternativa en estudio es el uso de nutrientes minerales (fósforo, potasio y boro), que generó incrementos interesantes del contenido sacarino en algunos casos. Este trabajo es una revisión de los estudios realizados por la EEAOC desde 1994, con el fin de encontrar un mayor número de productos que puedan ser utilizados como maduradores de caña de azúcar en diferentes condiciones agroecológicas.
Palabras clave: Caña de azúcar; Estrategia pre-cosecha; Herbicidas; Reguladores de crecimiento; Nutrientes minerales.
Introduction
Chemical ripening hastens crop maturity, thus
making high quality sugarcane available for its milling at an
earlier growth stage. This is particularly important in
achieving the goal of expanding the sugarcane production
area into regions not traditionally planted with sugarcane,
especially those with high probability of freeze occurrence.
In Tucumán, chemical ripening is the only pre-harvest
practice available that leads to significant increases in
sugar recovery levels, bringing about important economic
benefits (Leggio Neme et al., 2009). This technology has
been studied and promoted by researchers at the Estación
Experimental Agroindustrial Obispo Colombres (EEAOC)
since 1994, with excellent results. Adoption of chemical
ripening technology has resulted in an increase in the
sugarcane area treated with ripeners, from 3000 ha in
1997 to 115.000 ha presently, in Tucumán.
A review of chemical ripening in Tucumán, Argentina
The EEAOC started chemical ripening studies in
1994, and in 1997, after conducting several trials and
commercial scale demonstrations, it issued a series of
recommendations for the use of glyphosate as a sugarcane
ripener. In 1997, research on fluazifop-p butyl as a ripener
began at the EEAOC, which resulted in its recommendation
(Rufino et al., 2001). Later, evaluations of graminicides
(clethodim and haloxyfop-r methyl) and imazapyr continued.
In 2005, after six years of studies, the use of clethodim
was finally recommended for commercial fields (Leggio
Neme et al., 2005). However, haloxyfop-r methyl use did
not lead to acceptable results. In contrast, imazapyr was
very efficient and resulted in very satisfactory results.
However, there was no further research on imazapyr, as its
use was not economically feasible due to its high cost
(Table 1).
Table 1. Indices of response to ripeners (averages for cultivars, rates, and application stages) obtained by the Estación Experimental Agroindustrial Obispo Colombres (EEAOC) in Tucumán, Argentina, throughout the periods when they were evaluated.
(1): Total positive response tests (increases > 0.3 Pol % cane).
(2): Total high positive response tests (increases > 0.5 Pol % cane).
(3): Average increases for the following cultivars:
Glyphosate: CP 65-357, NA 63-90, TUC 71-7, LCP 85-376, TUCCP 77-42 and TUC 72-16.
Fluazifop, like glyphosate: LCP 85-384 and RA 87-2.
Imazapyr, clethodim, and haloxyfop: LCP 85-384, CP 65-357, RA 87-3 and TUCCP 77-42.
PK, B, trinexapac, sulfumeturon, ethephon and ethephon+graminicide: LCP 85-384 and TUCCP 77-42.
*OHT: optimal harvest time expressed as weeks after application.
In 2006, a new plant growth regulator (PGR),
trinexapac-ethyl, began to be evaluated as a potential
ripener. Trinexapac-ethyl inhibits the synthesis of
gibberellic acid Rademacher et al., 2000), thus delaying
growth. Trinexapac-ethyl was already being used in Brazil
as a ripener, along with sulfometuron-methyl (Dalley and
Richard, 2010). The latter has been evaluated since 2007,
with variable and inconsistent results (Table 1).
Furthermore since 2010, the effects of ethephon, a
PGR that releases ethylene (Marrero et al., 2004), has
been evaluated when used alone or in combination with
fluazifop-p butyl. Responses have been satisfactory and
consistent (Table 1), so this PGR has continued to undergo
evaluation to determine the ideal use rate.
The growing concern for risks posed by the use of
chemical products and their effects on the environment
and humans (Montano Martínez, 2002) has led to the
search for other alternatives that would successfully replace
these products. Since 2006, the use of mineral nutrients
like phosphorus, potassium and boron has been considered
as an alternative that would cause changes in the nutritional
balance, favouring maturation. Generally we observed that,
over five years, the use of mineral nutrients as ripeners
produced considerable sucrose content increases,
although in some cases significant differences were not
observed (Table 1).
In Tucumán, early applications were performed
between mid-March and mid-April, intermediate applications
in mid to late April, and late applications until mid-May. In
general, best responses were observed with early applications
(period with a minimum temperature of 14.8ºC and a
maximum temperature of 23.7ºC1), coinciding with the end
of the great growth period. Under these conditions ripeners
restrain vegetative growth rates, which results in increased
sucrose storage (Leggio Neme et al., 2009).
In conclusion, this paper has reviewed the extensive
work done by EEAOC researchers in order to test a great
variety of products that could be efficiently used as sugarcane
ripeners, under different agro-ecological conditions. This has
resulted in the availability of several and various technological
tools for growers and technicians, so that they can choose
the most suitable ones for each situation.
1Historical temperature data provided by Sección Agroteorología (EEAOC).
Cited references
1. Dalley, C. and E. Richard Jr. 2010. Herbicides as
ripeners for sugarcane. Weed Sci. 58: 329-333.
2. Leggio Neme, M. F.; E. Romero; L. Alonso; S. Fajre; P.
Fernández y A. Sánchez Ducca. 2009. Influencia
de la maduración química de los cañaverales en el
desarrollo de la zafra en Tucumán. Avance Agroind.
30 (3): 19-25.
3. Leggio Neme, M. F.; E. Romero; J. Tonatto; L. Alonso
y J. Scandaliaris. 2005. Cletodim: una alternativa
para la maduración química de la caña de azúcar.
Gac. Agroindustrial EEAOC (64).
4. Marrero, P.; H. Peralta; S. Pérez; J. Borroto y M.
Blanco. 2004. Efecto de aplicaciones exógenas del
Ethrel-480 sobre la anatomía del tallo, en cuatro
variedades de caña de azúcar (Saccharum spp.
híbrida). Revista Científica Caña de Azúcar, INIA
Venezuela, 22 (2): 5-18.
5. Montano Martínez, R. 2002. Maduradores en la caña de
azúcar. Revista Agricultura Orgánica, ACTAF Cuba
2: 12-15.
6. Rademacher, W.; K. Temple-Smith; D. Griggs and P.
Hedden. 2000. Growth retardants: effects on gibberellin
biosynthesis and other metabolic pathways.
Ann. Rev. of Plant Phys. and Molecular Biology 51:
501-531.
7. Rufino, M.; E. Romero; J. Scandaliaris; F. Pérez
Zamora and A. Bulacio. 2001. Agronomic, industrial
and economic impact of sugarcane chemical ripening.
Proc. Int. Soc. Sugar Cane Technol. 24 (2): 161-163..