Resumen

ANDRADE, E. M.; COSTA, B. L. C. M.; ALCANTARA, G. A. G.  y  LIMA, R. M. F.. Flotation of manganese minerals and quartz by sodium oleate and water glass. Lat. Am. appl. res. [online]. 2012, vol.42, n.1, pp.39-43. ISSN 0327-0793.

In this paper, we present the results and a discussion of microflotation tests performed with manganese minerals (rhodonite and rhodochrosite) and quartz mineral, using sodium oleate as the collector. We also explore the influence of water glass (sodium silicate) as a depressant in the recovery of these minerals with sodium oleate. Potential zeta determinations were carried out with the three minerals conditioned with deionised water and with the previously mentioned reagents. It was found that, at a pH of 9, the recoveries of rhodonite and quartz were maximised, and for the rodhocrhosite mineral, the maximum recovery was achieved at pH 11. The water glass at pH 9 was more efficient in depressing quartz than rhodonite, especially for smaller concentrations, whereas the flotation response of rhodochrosite was only slightly affected at both pH 9 and pH 11. The potential zeta curves indicate that the IEP of rhodonite (pH=2.8) is similar to values reported in the literature, whereas the IEP values of quartz (pH=2.2) and rhodochrosite (pH=10.8) differ slightly from those in the literature. The zeta potentials of rhodonite, quartz and rhodochrosite in the presence of sodium oleate and water glass become more negative in a basic medium. Finally, based on the experimental results with a collector of sodium oleate and a depressant of water glass, some inferences on the adsorption mechanisms of these reagents on rhodonite, quartz and rhodochrosite surfaces are made.

Palabras clave : Manganese; Rhodochrosite; Rhodonite; Quartz; Water Glass.

        · texto en Español     · Español ( pdf )